Posted: 8/29/2008 8:04:26 AM EDT
|
What purpose does the jacket over the compressor serve? I have been having HVAC problems, and the tech that came out found that the jecket that was supposed to be on the compressor was just lying inside the unit and not over the compressor like it should be. he also found where a mis-installed part had rubbed a hole in the coolant line, which is what caused me to have my problem. He says that the compressor's lifespan has been severely reduced and that we should have it replaced. It's still under warranty, but I'll have to pay a few hundred in labor. Could he be full of it, or does what he's saying sound plausible? What effect would the jacket not being installed have? |
| Yes oil travels in the coolant lines and he could add more if he has the proper tools. Any time you open up a system you could be hurting the lifespan of the equipment, exspecialy if it is not properly done. The only real reason for a compressor blanket is for sound deadning. |
| He's full of shit.Yes there is oil in the system to lubricate the moving parts in the compressor.If you have a leak you just fix that and then add a little oil.There will be no sightglass to judge the oil level so he'll just have to guesstimate how much to add--probably just a few ounces.The blanket is for noise reduction. |
|
The compressor blanket is only on there to supress the noise level of the compressor. There would have to be lot of oil out of the compressor for it to be done in. A little oil looks like a lot.  How many more months/years of warranty do you have left? If you are close to being out then have it replaced if not have him solder up the leak and see if it is still working.  BigDozer66 |
It's a 3-year-old Carrier. I forget the warranty. I'll have to look it up. I think it might have been ten years. Turns out the blanket wasn't his concern. I got that second-hand from my wife who was home when he came by. She didn't tell me about the oil. She thought he was worried because the blanket was off. |
| If you can get him to put the cost out of pocket to you in writing, getting a new compressor would be a good idea. Once it has run out of coolant and oil, and is open to the environment, there is a very good chance of contaminants getting into the system. With a new compressor install, they will purge the lines, or run new ones. Pull a vacuum and test for leaks. A few hundred in labor would be worth it in my opinion. |
He's bringing me a written quote in the morning. |
+1 Make sure they put a new filter dryer in it as well. |
He mentioned something to my wife about a new filter in the outside unit. He may have said filter dryer. |
Just for future reference...When it stops cooling go ahead and turn it off. It sounds like like started leaking slowly so it might not have ran that long without enough pressure to keep contaiminents out. Tell him you want him to put a "Low pressure cut out" protection switch on it while he is in there. They cost him less than $15.00 and it would be great insurance. If it is a Carrier HP I am surprised it doesn't already have one.  Have you called Carrier to see if there was some kind of recall that might involve the parts that were "installed" incorrectly? BigDozer66 |